This is for general posts and questions concerning only the Voyager XII (1200cc, Four-cylinder) Years 1986 thru 2003.
Moderators: the2knights , Highway Rider
2025 International Rally Reveal
Replies: 1
First post
2025_internal_rally_reveal.mp4
Last post
Seeing as I am familiar with most of the beautiful State of Minnesota, I thought I'd post some insights for the Rally attendess to consider as they...
1 Replies
8245 Views
Last post by SgtSlag
Tue Sep 03, 2024 6:59 pm
2024 AVA Blairsville GA, Closing Slide Show
Replies: 2
First post
2024_blairsville_ga_closing.mp4
Last post
Hi guys looks like a great time was had by all ,some great photos ,makes me feel like I was there .
2 Replies
4471 Views
Last post by ted1r
Wed Jun 26, 2024 12:29 pm
Need help on 91 Voyager xii
Replies: 13
by
Wilby64 »
Tue Apr 09, 2019 2:58 pm
First post
:-( rebuilding carbs and need help. I'm in Washington court house Ohio is there anyone near me who is able to help? Got the bike 4 years ago and...
Last post
I also remember something about using the old clips instead of new
13 Replies
871 Views
Last post by Me Again
Mon Apr 22, 2019 5:01 pm
Removing Oil Pan, Nails found crud, after using SeaFoam?
Replies: 8
by
SgtSlag »
Thu Apr 18, 2019 1:45 pm
First post
Nails, you got me curious with your post that you had to replace your oil pan, on your Voyager, and you still found crud in there after using...
Last post
Thanks for the insight. I know of the machines, and spectral analysis theory and principal (studied astronomy for years, their bread and butter...
8 Replies
652 Views
Last post by SgtSlag
Mon Apr 22, 2019 2:44 pm
hot tire pressure
Replies: 14
by
Nails »
Wed Apr 10, 2019 3:53 am
First post
For those with TPMS, what pressures do you run with the tires warmed up? About 45# for both?
Last post
My receiver sleeps , but I'm pretty sure the sending units are always on .
14 Replies
2714 Views
Last post by Nails
Sat Apr 20, 2019 3:19 pm
Adding Front Floor boards and changing exhaust
Replies: 11
by
jwcpastor »
Fri Mar 22, 2019 8:38 pm
First post
I wanted to know if there is a way to mount floor boards to replace the front pegs to get a heel toe shift on my 2003 Kawasaki Voyager XXI. Also, can...
Last post
.. yup.... BTDT... If I could just stretch'um out a couple more inches.....
11 Replies
1485 Views
Last post by cranky
Wed Apr 17, 2019 7:10 pm
Bumpy ride
Replies: 17
by
Hadyn »
Tue Apr 09, 2019 12:45 pm
First post
Hello
Last post
I found Progressives on front and rear improve the ability to pull the bike onto the center stand over the soft air suspension.
17 Replies
835 Views
Last post by Mr Jensee
Tue Apr 16, 2019 12:52 am
Ignition coil
Replies: 20
by
Thadbaker86voyager »
Tue Mar 19, 2019 9:16 pm
First post
Hey was wondering if you loose an ignition coil does it drop two cylinders, or one? I am thinking the coils are one coil, feeding two cylinders. Not...
Last post
Would like to get to a Rally, but this year isn’t going to be in the cards... :tho:
20 Replies
2898 Views
Last post by Thadbaker86voyager
Sun Apr 14, 2019 10:39 pm
Front and back plugs
Replies: 3
by
Hadyn »
Tue Mar 26, 2019 8:00 pm
First post
Hello
Last post
Saddle bag latch and tether info.
3 Replies
470 Views
Last post by 823JIM
Mon Apr 08, 2019 2:06 pm
New to Voyager questions
Replies: 2
by
Hadyn »
Sat Mar 23, 2019 9:34 pm
First post
Hello
Last post
I've seen some decent ones show up on Ebay from time to time. I would check there.
2 Replies
396 Views
Last post by Mr Jensee
Tue Apr 02, 2019 2:19 pm
Solo seat identification
Replies: 5
by
Hadyn »
Thu Mar 28, 2019 12:37 am
First post
Hello everyone.
Last post
There's a big difference between the Markland and Utopia backrest. The Markland adjusts front to rear. I found it wouldn't maintain enough pressure...
5 Replies
542 Views
Last post by Barry
Tue Apr 02, 2019 1:19 pm
7.5 fuse
Replies: 2
by
Hadyn »
Wed Mar 27, 2019 7:12 pm
First post
Trying not to as the same questions on the radio. But I have replaced the 3amp and 1 amp looked at the amp on the amplifier it's good. Is there...
Last post
Thanks
2 Replies
375 Views
Last post by Hadyn
Sat Mar 30, 2019 1:11 am
Replacement Key
Replies: 14
by
TheWhiteDevil »
Mon Mar 25, 2019 10:16 pm
First post
So Long story short, I finished rebuilding a 1989 zg1200 from a previous owner and shops start and failure to complete state. Ran it for 1 day and...
Last post
I suggest Pop a Lock. I have used them a few times here and they are quick professional and reasonably priced.
14 Replies
1069 Views
Last post by Mr Jensee
Fri Mar 29, 2019 10:25 am
How to turn off HS on radio
Replies: 4
by
Hadyn »
Wed Mar 27, 2019 9:25 pm
First post
Hello
Last post
Be aware, that snake will raise it's ugly head, again!
4 Replies
518 Views
Last post by Bill O
Fri Mar 29, 2019 3:03 am
7.5 fuse
by
Hadyn »
Wed Mar 27, 2019 7:12 pm
Trying not to as the same questions on the radio. But I have replaced the 3amp and 1 amp looked at the amp on the amplifier it's good. Is there...
0 Replies
240 Views
Last post by Hadyn
Wed Mar 27, 2019 7:12 pm
Final drive O ring
Replies: 2
by
bigmac7139 »
Tue Mar 26, 2019 11:08 pm
First post
I am trying to see if anyone knows where to obtain part number 92055-1037 that is currently unavailable except on eBay at $10 dollars a pop. Assuming...
Last post
92055-1646 is the new, superseded part # for the old # 92055-1037.
2 Replies
332 Views
Last post by triton28
Wed Mar 27, 2019 10:28 am
6 Replies
701 Views
Last post by Van Voyager
Tue Mar 26, 2019 12:01 am
Another 03 Voyager
Replies: 14
by
razorback13 »
Mon Mar 11, 2019 12:39 am
First post
Ok found another 03 Voyager , this one is super clean less than 5,000 miles and one owner . After my death wobble incident with my last one I've been...
Last post
Haven't bought the bike yet not sure I'm going to .
14 Replies
868 Views
Last post by razorback13
Sun Mar 24, 2019 1:37 pm
Radio
Replies: 7
by
rjwelsh »
Fri Mar 08, 2019 7:30 pm
First post
The face plate on my radio doesn't work. Looking to buy a radio for a Voyager XII . Working with Sierra Electronics to get it working. I will buy a...
Last post
I just got a voyager VII radio from Pete Franchi upgraded to the 21st century with Bluetooth.
7 Replies
585 Views
Last post by VoyKimmer
Thu Mar 21, 2019 12:37 am
Quiet Ride inserts
Replies: 14
by
Nails »
Sun Aug 12, 2018 2:11 am
First post
I believe that there are two kinds of helmets in the world, loud ones (expensive) and louder ones. I decided to install Quiet Ride ear muffs in my...
Last post
I'm giving up on the Quiet Ride inserts. I couldn't install them as intended because there wasn't enough room in my helmet (a 2XL). I couldn't use...
14 Replies
1374 Views
Last post by Nails
Sun Mar 17, 2019 10:45 pm
Identify year by colour...
Replies: 1
by
stevejinde »
Sat Mar 16, 2019 2:52 pm
First post
Hi Folks.
Last post
From AB Bike Board
1 Replies
356 Views
Last post by VoyKimmer
Sat Mar 16, 2019 4:51 pm
Knob, On 1986 Voyager. Left side, below storage box
Replies: 19
by
PaulRanda11 »
Sun Mar 03, 2019 6:20 pm
First post
Hi Everyone,
Last post
Bulrid8,
19 Replies
1203 Views
Last post by PaulRanda11
Sat Mar 16, 2019 1:33 pm
Choke cable
Replies: 2
by
johnnyreb »
Fri Mar 08, 2019 8:13 pm
First post
I dont know where else to look. I need a choke cable for a 2001 voyager1200 i have bought 3 different ones but they are the wrong ones. On mine the...
Last post
Are you ordering P/N 54017-1095 ? It’s called a starter cable. Make sure you order OEM. There only about $30.
2 Replies
314 Views
Last post by VoyKimmer
Sat Mar 09, 2019 12:31 am
BATTERIES-BATTERIES AND MORE QUESTIONS
Replies: 2
by
ekap1200 »
Tue Mar 05, 2019 11:04 pm
First post
Between this site and a few others concerning Voyager 1200 batteries I thought I would post some of YUASA'S P/N's of their 2 that are usable in our...
Last post
I had a Yuasa AGM in my Kawasaki ZRX1100 for 8 years before it finally gave up the ghost. I kept the bike on a maintainer charger all the time I...
2 Replies
368 Views
Last post by Mr Jensee
Thu Mar 07, 2019 5:33 pm
Deka ETX-18L battery
Replies: 23
by
Nails »
Sun May 06, 2018 2:55 am
First post
This is an AGM (Absorbed Glass Mat) maintenance free design. Lots of praise in webistan.
Last post
Well, this time I'll avoid killing the battery with excessive compression testing, a stuck starter solenoid, and then an abused/abusive charger.
23 Replies
2947 Views
Last post by Nails
Sun Mar 03, 2019 5:09 pm
voltmeter
Replies: 11
by
Nails »
Wed Feb 13, 2019 9:14 pm
First post
I bought this voltmeter: , about $64 with shipping (and showed up pronto). I got it because of rave reviews (especially regarding accuracy) and it...
Last post
They seem awfully similar. Specs might be, too. Mine is a little more expensive, lives entirely under the fairing and out of the weather (no exposed...
11 Replies
1191 Views
Last post by Nails
Fri Mar 01, 2019 2:45 am
heated grips again
Replies: 15
by
Nails »
Tue Oct 16, 2018 1:44 am
First post
What grip heaters (element) or heated grips work well on XII? When I searched, I found some recommendations from 4 years ago. Any updates?
Last post
I have full leathers too, but honestly not any warmer. I'm just now going to synthetics for long trips because more versatile. Like the armor --...
15 Replies
1412 Views
Last post by Nails
Thu Feb 28, 2019 12:47 am
Forum permissions
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forumcannot post attachments in this forum
