Got a tech tip for Voyager 12's from your personal experiences, or one complete with pictures and instructions, here's where to post it. You can also ask about tips or procedures here.
Moderators: the2knights , Highway Rider
2025 International Rally Reveal
Replies: 2
First post
2025_internal_rally_reveal.mp4
Last post
Hi guys I hope you are all ok that side of the pond ,my question is as follows ,
2 Replies
35682 Views
Last post by ted1r
Wed Dec 04, 2024 6:04 pm
2024 AVA Blairsville GA, Closing Slide Show
Replies: 2
First post
2024_blairsville_ga_closing.mp4
Last post
Hi guys looks like a great time was had by all ,some great photos ,makes me feel like I was there .
2 Replies
35467 Views
Last post by ted1r
Wed Jun 26, 2024 12:29 pm
Homebrew or Reinforced CB Antenna Mount ??
Replies: 5
by
Ohio Mike »
Wed Oct 05, 2011 1:39 pm
First post
Just wondering if anyone has built their own or reinforced the stock CB antenna mount.
Last post
I am running a whip antenna that is about 6 shorter than the stock Am/FM antenna. I cut the stock antenna off to match the length of the CB antenna....
5 Replies
798 Views
Last post by vxiirider
Wed Dec 28, 2011 1:24 am
coolant O rings
Replies: 1
by
djones100rt »
Tue Dec 27, 2011 7:51 pm
First post
Is the O ring part number listed as 92055-1350 the kawasaki number for the coolant manafold at the front of the engine. Thanks Dave
Last post
yes, the 1350s are for the cylinder manifold......
1 Replies
382 Views
Last post by carl leo
Tue Dec 27, 2011 7:58 pm
maintinence
Replies: 4
by
bikermike »
Sun Dec 11, 2011 3:16 pm
First post
Well sadly,, both my bikes are stabil treated and tucked away in a cold garage for the winter... sighhhh.... At any rate, my voyager is a 91 with 50k...
Last post
Many years ago I changed out fork seals on a GS1000L but I can't remember if they were OEM or aftermarket. Since the forks were also air type and...
4 Replies
628 Views
Last post by Mr Jensee
Mon Dec 12, 2011 11:23 am
1248 IGNITER LOANER
Replies: 14
by
JHD »
Mon Oct 31, 2011 2:37 am
First post
I have been troubleshooting my '92 and suspect a problem with the igniter, Pete Franchi was kind enough tonight to go through some troubleshooting...
Last post
Happy Thanksgiving all.
14 Replies
1302 Views
Last post by JHD
Thu Nov 24, 2011 9:41 pm
Electrical Problems trying to add lights
Replies: 14
by
usmalenurse »
Thu Sep 01, 2011 1:09 am
First post
Bought some LED lights to add to the rear of the bike and started working on them today. Just added a small led to the right saddlebag and it was...
Last post
Pasam..I set here typeing reply for around 1/2 hour, only to have some OVERSEER make it magically disapear!
14 Replies
2046 Views
Last post by debron
Tue Nov 01, 2011 5:00 am
No more floppy mirrors
Replies: 3
by
gearheadfla »
Wed Oct 12, 2011 9:03 pm
First post
My mirrors have been driving me nuts latley falling at highway speeds or when hitting bumps, I have seen on here how to drill hole and tighten then...
Last post
Well, Went to Daytona, rode two days around there plus the 240 or so mile round trip there and back and didn't have to touch mirrors once :thmup:...
3 Replies
486 Views
Last post by gearheadfla
Wed Oct 19, 2011 3:21 am
off idle stumble
Replies: 2
by
bikermike »
Mon Oct 17, 2011 12:34 am
First post
Hi all!!
Last post
Adjust and Lube cables along with cruise cable...if no change have carbs synced..other possibility is leaking boot on carb plungers. lilabner
2 Replies
452 Views
Last post by lilabner
Tue Oct 18, 2011 1:51 pm
Windshield Rain Guard or Edging
Replies: 3
by
gbakman53 »
Fri Oct 14, 2011 2:35 pm
First post
Has anyone ever put a rain guard edging on the windshild to help kept rain from running up and over
Last post
Thanks for the info. Plan to order some of the edging next week.
3 Replies
622 Views
Last post by gbakman53
Sat Oct 15, 2011 7:08 pm
Speedo cable replacement
Replies: 6
by
joerod777 »
Mon Oct 10, 2011 11:29 pm
First post
I'm replacing the speedometer cable on my 2003 Voyager. I've read about lubricating the new cable with a lithium grease or a speedometer cable...
Last post
Installed new speedo cable today. Everything works fine. I also put shrink wrap over the cable sleeve to keep water out. Thanks for all the advice!
6 Replies
1177 Views
Last post by joerod777
Fri Oct 14, 2011 10:55 pm
Pretty Brake Lines-HELP
Replies: 4
by lilabner » Tue Oct 11, 2011 11:33 pm
First post
Can some one tell me where to get those nice front brake lines, stainless braided & coated with a clear coating? Never did get a chance to catch the...
Last post
NorCal Voyagers sells them, just email president@norcalvoyagers.org I'll get right back to you.
4 Replies
570 Views
Last post by HMB Don
Fri Oct 14, 2011 10:01 pm
antenna
Replies: 1
by
biker4life »
Tue Oct 04, 2011 7:34 pm
First post
hi all, my reception suddenly went really bad on the radio, and as i was checking it all out, i noticed the black plastic piece that holds the...
Last post
I'm assuming you have the 1200. The black plastic section, the base is supposed to unscrew for removal. I suspect something has broken in the base...
1 Replies
488 Views
Last post by Mr Jensee
Tue Oct 04, 2011 11:49 pm
Fuel Tank removal
Replies: 6
by
Bruce in OK »
Fri Sep 30, 2011 1:15 am
First post
I'm e-mailing Carl as well, but how difficult is it to remove the fuel tank from the 1200? Either I bought some bad gas that I can't get cleaned out...
Last post
Way to go!!!!! As I said before, I had you problem. I was thinking about adding a filter after the fuel pump to just make sure but I don't know if it...
6 Replies
3293 Views
Last post by davidl
Sat Oct 01, 2011 12:33 am
Intercom
Replies: 11
by
Skibou »
Fri Jul 01, 2011 12:02 am
First post
After wasting a couple of hundred dollars, and two years of frustration messing with a self contained intercom system ( If I had any hair, I would...
Last post
sierra electronics
11 Replies
1768 Views
Last post by biker4life
Fri Sep 30, 2011 10:29 am
aux thermostat ground lost?
Replies: 5
by
richardb, austin »
Fri Jul 29, 2011 3:55 pm
First post
My bud applied the auxilliary thermostat ground-fix with good success. As a matter of fact his temp gauge was capable of reading quite high on the...
Last post
It turned out to be the O.E. thermostat wire connection. Female half needed crimping. Now his temp gauge works better than mine (again), but I still...
5 Replies
497 Views
Last post by richardb, austin
Thu Sep 01, 2011 7:34 pm
fuel in surge or catch tank
Replies: 3
by
ithitwhat »
Sun Aug 21, 2011 11:57 pm
First post
I have a 1996 XII and recently it has started backfiring on decelaration and I am getting gas mixed with a small amount of water in the catch tank. I...
Last post
Or bad float needles; ethenol gas is killin carbs in Voyagers. Call Carl. I got very good at taking the carbs off too.
3 Replies
532 Views
Last post by davidl
Tue Aug 23, 2011 2:28 am
Alternator Trouble Help Help
Replies: 2
by
NavMode »
Sun Aug 14, 2011 12:14 am
First post
I've read the post on this subject but still have a question..
Last post
The only parts available for the 1200 alternator are the brushes. It is possible they are wore out and need replaced. Most find that around 60,000...
2 Replies
919 Views
Last post by Rhinestone Kawboy
Sun Aug 21, 2011 12:25 am
cruse\brake light switch adjustment?
Replies: 8
by
twopass »
Wed Aug 10, 2011 9:03 pm
First post
My cruise will work if if push the switch forward but that makes the brake light come on ,pushing the break lever out will not let the cruise work,...
Last post
I had to gently sand/grind/machine my lever on the '01 just a hair so both switches would get tripped.
8 Replies
987 Views
Last post by Chris near Kansas City
Wed Aug 17, 2011 3:41 am
Passenger remote control cover
Replies: 3
by
joerod777 »
Sun Jul 31, 2011 5:57 pm
First post
On my 2003 Voyager the velcro has worn out on the vinyl bag that covers the passenger's remote control. I would fasten the velcro only to find it...
Last post
PICS
3 Replies
646 Views
Last post by twopass
Wed Aug 10, 2011 10:01 pm
My '02 is trying to act like an older Harley - leaking oil
Replies: 10
by
Andy(SC) »
Fri Jun 17, 2011 3:37 pm
First post
My '02 has never left a drop on the garage floor and has been clean underneath. About 2 weeks ago I drove it 10 miles or so from my old place to a...
Last post
She was just marking her new territory . :gig: :gig: :gig:
10 Replies
2282 Views
Last post by pasanby
Mon Aug 01, 2011 4:17 pm
Junk in the trunk
Replies: 2
by
wolverine392ih »
Sun Jul 03, 2011 3:25 am
First post
I purchased my bike after it had been in a rear end bump up. I check out all of the major mechanical parts and they are ok. My problem is that the...
Last post
What're you gonna do with all that junk, all that junk inside your trunk..... B.E.P.
2 Replies
545 Views
Last post by Chris near Kansas City
Sun Jul 24, 2011 11:46 pm
Cheap heel toe shifter bracket on Ebay.
Replies: 1
by
suzib6sw »
Tue Jul 19, 2011 6:31 pm
First post
Dont know if its anyone here but someone is making a Heel toe shifter for the Voyager.. Simple, effective and not to hard to add either..
Last post
I wonder if they drilled the holes off center on purpose. :hmm:
1 Replies
444 Views
Last post by David (N. Alabama)
Tue Jul 19, 2011 8:28 pm
Anyone have a VN750 Vulcan ignitor?
by
suzib6sw »
Tue Jul 12, 2011 3:39 pm
Been examining the pics of a VN750 ignitor and they bear a more than passing resemblance to the Voyagers minus the vacuum advance..
0 Replies
226 Views
Last post by suzib6sw
Tue Jul 12, 2011 3:39 pm
Junk in the trunk
Replies: 2
by
wolverine392ih »
Sun Jul 03, 2011 3:24 am
First post
I purchased my bike after it had been in a rear end bump up. I check out all of the major mechanical parts and they are ok. My problem is that the...
Last post
Thanks for replying Icebird. I broke down and ordered a couple of nylon bushings. Thanks Carl. If these give me any trouble I'm going to mill some...
2 Replies
525 Views
Last post by wolverine392ih
Wed Jul 06, 2011 1:27 am
Tech Page's Save the Day....Again!
Replies: 1
by
Bill O »
Wed Jun 22, 2011 3:54 am
First post
Got a call from a friend on the road..... Met up with a buddy in Chicago....... friends Voyager 1200 stopped running over night...... Bad...
Last post
Isn't this forum great, or what?
1 Replies
369 Views
Last post by debron
Wed Jun 22, 2011 4:07 am
MP3 Mod for the Voyager XII Radio & LCD color change pics
Replies: 10
by
suzib6sw »
Wed Nov 03, 2010 3:09 pm
First post
Ok.. Last night I looked at the front panel as a whole on the test bed
Last post
Yes you too can Tan at night ;-)
10 Replies
2044 Views
Last post by suzib6sw
Tue Jun 21, 2011 3:15 am
Forum permissions
You cannot post new topics in this forumcannot reply to topics in this forumcannot edit your posts in this forumcannot delete your posts in this forumcannot post attachments in this forum
